• Please be sure to read the rules and adhere to them. Some banned members have complained that they are not spammers. But they spammed us. Some even tried to redirect our members to other forums. Duh. Be smart. Read the rules and adhere to them and we will all get along just fine. Cheers. :beer: Link to the rules: https://www.forumsforums.com/threads/forum-rules-info.2974/

How do you set an RV up for high altitude/cold weather travel?

Dargo

Like a bad penny...
GOLD Site Supporter
I'm planning on taking my family out west on a 3 week vacation this summer in our coach and know from experience that we will likely get into areas where the ambient temperature is below 32 degrees. I wrote the manufacturer of my motor coach and asked them if they have a "cold weather" kit or something similar. I was surprised to get this response:

Good Morning!

Thank you for contacting Fleetwood RV. Although your motor home is advertised with heated water and holding tank compartment, unfortunately, we can only recommend that units be winterized if you will be in temperatures of 32 degrees or below. We cannot guarantee they will not freeze, nor can we make recommendations for after market products or modifications. Please accept our apologies for any inconvenience. Thanks again.

Donna R. Roe
Sr. Administrative Specialist


I know that not all RV's are limited to warm weather areas. Besides, for an initial sticker price around 300k, you would think this coach just might be setup for such travel. I suppose that much doesn't buy you much anymore. :mellow: Anyone have any ideas of places that may sell kits for cold weather travel and camping? I'm sure I could rig up some insulation with heated 12v tape inside it and attach it to either a cheapo switch or, better, some thermostat to kick on and keep my fresh water tank and water lines protected from freezing. It's great if my holding tank and fresh water tank and holding tanks won't freeze, but neither will do me much good if the lines to them are frozen.
 

Doc

Bottoms Up
Staff member
GOLD Site Supporter
I would be rather concerned about electrical tape in a small closed in area where you pipes probably are. Leave the door to the areas (where the lines are) open and a little space heater might be slightly safer.

Like you I'm surprised at the response you got. These things are made to travel all over but they can't handle temps below 32 and still function with hot and cold water etc. :confused: I wonder how the stars handle that who travel in those things year round. There has to be a way to make them functional year round.
 

REDDOGTWO

Unemployed Veg. Peddler
SUPER Site Supporter
If your motor home has a heated basement there should not be a problem provided all tanks are in said basement.
 

bczoom

Super Moderator
Staff member
GOLD Site Supporter
Brent,

We did a similar trip in an RV a couple years ago. We were in high altitudes (e.g. Colorado) and as far north as southern Montana. The RV we had was nothing compared to yours but we had no problems.

As Reddog mentioned, your tanks are in a heated area and shouldn't freeze. Also, the water lines are probably pex so it won't be damaged should it freeze.
 

muleman

Gone But Not Forgotten
GOLD Site Supporter
Check your compartments where the water lines run and see if you have any heat ducts from the furnace in there also. Cut in a T in the heat duct and put a magnetic cover over the register on that line. A half cover should give enough restriction to force some heat out in the pipe area. A good idea to dump some rv antifreeze in your holding tanks and pop the valves till you get some of it coming out. They will freeze quick running down the road and a blow dryer works well to free them up for dumping. Don't force them or you will have a mess on your hands.
 

jimbo

Bronze Member
GOLD Site Supporter
Thank you for contacting Fleetwood RV. Although your motor home is advertised with heated water and holding tank compartment, unfortunately, we can only recommend that units be winterized if you will be in temperatures of 32 degrees or below. We cannot guarantee they will not freeze, nor can we make recommendations for after market products or modifications. Please accept our apologies for any inconvenience. Thanks again.

Now that is a confusing statement.

You just don't get as much for 300K as you used to.
 

Dargo

Like a bad penny...
GOLD Site Supporter
If your motor home has a heated basement there should not be a problem provided all tanks are in said basement.

Nope, they freeze. Already been there unfortunately. Only holding tanks and fresh water tank heated. This coach is setup for long term runs. It has a huge 100 gallon propane tank between the frame rails, 150 gallons of fresh water and takes on 150 gallons of fuel. In that configuration there is no 'full basement'. The water lines are simply out in the open.

I'd assume the people who ordered it new, based on what receipts I've found, took 2 weeks trips to FL in it and had plenty of propane to run the fridge, oven, heater, water heater for the entire trip and they likely only had to refill the fresh water tank and dump once before heading back home. Clearly they never traveled in cold weather. I have pictures from about 10 years ago of us camping in the northern Rockies in late July and it was snowing pretty good where we were.
 

REDDOGTWO

Unemployed Veg. Peddler
SUPER Site Supporter
That is unfortunate, my 94 31 foot Bounder has everything in the heated basement where the tanks and lines will not freeze, do what temperature I do not know but I have been in it in weather in the 20's without a problem. The only thing it that I checked it and it looked frozen so I opened the valve and was deluged with unfrozen waste water, the tank valve to the gray water tank had not been closed.
 

Dargo

Like a bad penny...
GOLD Site Supporter
I started to comment that I don't care if my waste tanks are heated and why would they heat them and not the others etc., then I thought about it. It's bad if you have no water, but worse if you have frozen crap you can't get rid of. If it froze your little roundy flusher thingy at the bottom of the toilet open that would really be a bad thing.
 

tommu56

Bronze Member
GOLD Site Supporter
Aren't the pump and lines up in the cabin area? they should be good with the heater on.
Will you be driving much? or in a camp ground with utilities?
The fresh water tanks shouldn't freeze solid over night

The black and gray water will take more cold than the fresh before they
freeze.

I have an hybrid trailer and haven't had any thing freeze with it down in the upper 20' at night but my water tank in in the trailer and the heater on and my "tent ends don't provide any insulation.
My cabin has water in it alot when the out side temp dips beow 32 and I haven't done any damage yet I have a recording thermometer in the cabin with a remote out side and its usually 10 degrees warmer in side than outside for the low temp.

dtr900_lg.jpg


http://www.thermoworks.com/products/low_cost/dtr900.html

tom
 

Dargo

Like a bad penny...
GOLD Site Supporter
Aren't the pump and lines up in the cabin area? they should be good with the heater on.
Will you be driving much? or in a camp ground with utilities?
The fresh water tanks shouldn't freeze solid over night

The black and gray water will take more cold than the fresh before they
freeze.

I have an hybrid trailer and haven't had any thing freeze with it down in the upper 20' at night but my water tank in in the trailer and the heater on and my "tent ends don't provide any insulation.
My cabin has water in it alot when the out side temp dips beow 32 and I haven't done any damage yet I have a recording thermometer in the cabin with a remote out side and its usually 10 degrees warmer in side than outside for the low temp.

dtr900_lg.jpg


http://www.thermoworks.com/products/low_cost/dtr900.html

tom

All lines run under the coach and between the frame rails on the Freightliner chassis. Therefore, they all are exposed to the ambient temperature.
 

mbsieg

awful member
GOLD Site Supporter
we had weather here last fall in the -20 early last fall. My bus was fine with just the furnace on. All of my local camping is at min 8000ft I would not worry at all with exposed lines at 25 degrees as your coach will radiate some heat through the floors. I would assume when you level the bus it will be fairly close to the ground. Heat rises it should have its own little micro climate under the bus. If the highs were in the 30 degree range for the day it would be different, but mid July even at 10000 ft you will still see daytime highs of at least 50. People around these parts leave there campers on the Mtn from labor day till Late Nov alot of times. Dont worry have fun call if you are in the area the locals might just know some great spots!!!
 

fogtender

Now a Published Author
Site Supporter
As long as you have the heat on, and not going much below freezing for a bit, not much will be needed. As far as the High Alt. part, if your engine is newer fuel injected version of the gas engine or a diesel, the computer will take that into consideration and lean the fuel settings for you.

If you have one of the really old versions of a motor home, then your jets need to be adjusted for the higher alt. that you may be driving at, and your pipes will freeze... Just kidding about the freezing part.

Should freezing really be an issue, drain all your water tanks and fill up the main tank with about ten gallons of RV anti freeze, then flush the lines til red comes out of all the faucets, but before that, drain out your hot water heater, when you pump the RV anti freeze into it, it will fill up with the fluid and you should be good to about -40 or so. But having the RV antifreeze in the system, you can still flush the toilet and such when you want.

The stuff is designed to be used in fresh water systems and can be drank, but won't taste good so you need to flush the stuff out when you are going to be in a real summer with heat. You can dilute the RV antifreeze with water for more in the system and still be good, I doubt you are going to be in extreme cold during the month of May or June.

Have a great trip!
 

NorthernRedneck

Well-known member
GOLD Site Supporter
Click on this link and see #6. Every time I hear someone talk about camping in colder temps, I hear them mentioning how they play on putting heat tape on the external water lines. When we go out for May long weekend, quite often, it's cold and below freezing at night. We often wake up to a nice thick layer of frost over everything and sometimes a thin layer of snow. We've been camping in that kind of weather for as long as I've been on this earth and have never had a single problem with the water lines and tanks. And that's without the heat tape.

http://www.happyvagabonds.com/Rving Guide/RV Camping In The Winter.htm

As fogtender mentioned, as a precaution, you might want to keep a few jugs of rv antifreeze on hand and dump some in your tanks before heading out. I try to stay away from putting it right in the fresh water tank and simply close the valve coming from the tank going to the water lines. If you can survive without running water, this would be the way to go. Just make sure the fresh water tank is fully drained then close the feed line from the tank and open the valve going to the external hose that you would put into a jug of rv antifreeze. Then, run your pump opening each faucet in the camper for a few seconds each till you see the antifreeze coming out of the fixture. Only thing with this method is that you won't be using the toilet.
 
Last edited:

Bulldog1401

Anybody seen my marbles?
SUPER Site Supporter
Dad has a very large horse trailer (sundowner with living quarters forward) that is set up for cold weather in that it has heating mats on the bottom of all tanks that keep them liquid no matter how cold it gets. Have You considered running your heater core hoses beside the waterlines and wrapping them together in a blanket of insulation? this would probably go a long way toward getting things moving again should they freeze.
 

fogtender

Now a Published Author
Site Supporter
Click on this link and see #6. Every time I hear someone talk about camping in colder temps, I hear them mentioning how they play on putting heat tape on the external water lines. When we go out for May long weekend, quite often, it's cold and below freezing at night. We often wake up to a nice thick layer of frost over everything and sometimes a thin layer of snow. We've been camping in that kind of weather for as long as I've been on this earth and have never had a single problem with the water lines and tanks. And that's without the heat tape.

http://www.happyvagabonds.com/Rving Guide/RV Camping In The Winter.htm

As fogtender mentioned, as a precaution, you might want to keep a few jugs of rv antifreeze on hand and dump some in your tanks before heading out. I try to stay away from putting it right in the fresh water tank and simply close the valve coming from the tank going to the water lines. If you can survive without running water, this would be the way to go. Just make sure the fresh water tank is fully drained then close the feed line from the tank and open the valve going to the external hose that you would put into a jug of rv antifreeze. Then, run your pump opening each faucet in the camper for a few seconds each till you see the antifreeze coming out of the fixture. Only thing with this method is that you won't be using the toilet.


Naw, you can use the toilet with the RV anti freeze in it, matter of fact, the black water tank won't freeze either... Use to do that for winter camping and used the toilet for emergencies, because there was no place to dump the tank in winter... you had to pick and choose your emergencies...:whistling:
 

Dargo

Like a bad penny...
GOLD Site Supporter
Thanks for the replies. I now realize I haven't provided much info on the coach which, obviously, would be helpful. It's a 2004 diesel pusher with a Cat C9, turbo diesel, engine in the back. The only time we experienced the lines starting to freeze over was coming back from FL in early January. That's also when I found, going up Mt. Eagle, that a diesel pusher will go like crazy up hills in snow and ice, but won't turn worth a hoot. :eek: Between the all wheel ABS and jake brake, it slowed okay coming down.

Once at the bottom on the north side of the mountain, the ambient outdoor temp display was showing about 23 degrees. I suppose the first few "oh shit", it won't turn!" comments from me gave her reason to use the can on the other side of the mountain. Only then did I discover something was wrong when she said the toilet wouldn't flush. A quick look at the gauges showed the "black" tank only 1/4 full, gray 1/2 full and still about 75 gallons of fresh water. I also had the water heater off since I wasn't planning on taking a shower before we got home.

I immediately flipped the water heater on and pulled over at the next rest stop. After about 5 minutes I got one of the faucets to start dribbling then flowing then running normal. Not knowing any other option, and wanting to keep the toilet option available with 6 of us in the coach, I just slightly opened all of the sink faucets; hoping I had enough fresh water to keep flowing the rest of the way home. I did, with about 50 gallons to spare.

Maybe that gives a little more of a true picture of the issue. Under the coach I can see all the water lines in the open clipped to the frame rails running the length of the coach. When driving, nothing put warm air under the coach since it's a diesel pusher. It has a 4 cyl Kubota diesel under the front for a generator, but I don't think it would put out much heat since it's liquid cooled and has it's own radiator. This is why I think I need to somehow insulate and slightly heat the lines (heat above freezing). It doesn't look like the large fresh water tank is properly protected either. It's clearly an optional larger tank and it looks like only about half is protected.

Hopefully this sheds a little more light on the dilemma. And, yes, what you guys living at altitude expressed is exactly what I experienced; nights well below freezing but temps at least in the 40's during the day. Dropping the air ride suspension before hitting the auto leveling jacks does keep it a bit lower to the ground, but the darn jacks do raise it a bit. Still, if that is my only issue, I feel that putting a little ceramic space heater on the ground under the coach at night would keep things from freezing as I'm sitting still. I'm mainly concerned about any winter travel. I keep thinking someone would have to sell some sort of insulating and heating kit for RV's.
 

Snowtrac Nome

member formerly known as dds
GOLD Site Supporter
if you are worried about freezing that much here is what we do up here in the arctic where our domestic service runs through perma frost there is a circulating pump that keeps the water moving as long as the water is moving it isn't going to freeze insulation around the pipes will help and antifreeze in the black and grey tanks is a good idea so you can dump them be more worried about the plumbing than the tanks as the chance for damage is more likely going to happen in your pipes
 

Dargo

Like a bad penny...
GOLD Site Supporter
I'm back to this issue. Since there is a distinct possibility that I may need to take my daughter to Boston in my coach and live in it or a while, I an in desperate need of trying to find a company who can modify my RV to operate in sub freezing temps. I'm severely hampered in my current ability to do the work, so I'd pretty well have to buy some "kit" of sorts if I'm going to do the work.

I'm so pissed at our local RV dealers that hell will freeze over before I'd buy a single gallon of RV antifreeze from them. After all but begging them to give me a price on doing a conversion to keep my exposed water lines, fresh, gray and black water tanks from freezing they flat refused to do any work on my RV since I didn't buy it from them. I really don't think the RV, especially the middle to higher end, business is booming right now. I think that attitude is a guaranteed way to go out of business.

Anyway, anyone have any ideas? I've seen temp controlled 'heating' pads for the tanks that draw very little and just keep the temps above about 40 degrees. That just leaves the dumping valve area and a few exposed supply lines. It seems like I could buy some heated tape/wrap for them hopefully controlled by a thermostat. If not, heck, I can just run them off a variable voltage dial or, at worse, a toggle switch. I just can't find anything.
 

muleman

Gone But Not Forgotten
GOLD Site Supporter
If you are willing to run your generator a good bit you could use regular heat tapes and wrap the lines and insulate them. The tanks with some rv antifreeze in them won't be that big of a deal but the valves to dump them will need tape and insulation to protect them going down the highway. I would use foam insulation and good tape like gorilla tape to hold it in place. Fiberglass will absorb water and salt slush too much. Wrap all the lines with the tape running from front to back so the air is less likely to unravel it.
 

Danang Sailor

nullius in verba
GOLD Site Supporter
There are RV's that are made with closed bottoms that are specifically designed for cold weather use. That being the case, it should be possible to install the necessary parts on the one you have now. We have had much good luck with the Camping World folks; based on your public data I'm guessing this is their location closest to you:

Bath, NY
500 West Morris Street
Bath, NY 14810
phone.gif
8668517700
phone.gif
More Info
If you give them a call and explain your situation they may very well be able to help, or at least point you in the right direction.

Good Luck!!
 

muleman

Gone But Not Forgotten
GOLD Site Supporter
Danang, That is a local place to me but Dargo is in Indiana. That local dealer is where we hold the pet expos when the weather is nice.
 

mbsieg

awful member
GOLD Site Supporter
Haybales......... Yep thats your answert haybales and a knipco heater. and maybe a flaming cat. On a serious note Rent a motel room monthly or a house nearby a RV not set up for winter is going to cost alot of $$$$$$$$ to make it winterable. will the furnace even keep up? they sell them as 1 season units for a reason. It would e cheaper to trade it off for a 4 season pusher than put a belly under that one.
 

tommu56

Bronze Member
GOLD Site Supporter
I would call around to another RV dealers in your area and ask them it doesn’t have to be a Fleetwood dealer ask some friends for recommendations look at the yahoo groups or other RV forums for suggestions.

Tom
 

XeVfTEUtaAqJHTqq

Master of Distraction
Staff member
SUPER Site Supporter
On a serious note Rent a motel room monthly or a house

+1 Dargo, you can afford to stay at a Residence Inn or something equivalent (Extended Stay type place) - just get one of those and be done with it. You don't want to be dealing with a monster RV in Boston.
 

Dargo

Like a bad penny...
GOLD Site Supporter
+1 Dargo, you can afford to stay at a Residence Inn or something equivalent (Extended Stay type place) - just get one of those and be done with it. You don't want to be dealing with a monster RV in Boston.

I don't know how long the stay will be or even if we may need to move to a different location every week or two. I've already dropped a few thousand in hotel stays. So, in my mind, it's either time to dump the RV if it's completely useless for our needs or make it work. It's so open with so much room to operate under it that it sure looks like a simple job with the right materials. I've already spent probably 2 or 3X what it will cost to make it work in hotel bills, and the hotels were NOT that great. Having my "hotel" in the back lot of the hospital sure has it's advantages; especially with my own laundry, no strange smells, bugs etc.

If you can't get an RV setup to operate in cold weather for under 200 grand, I am completely out on owning an RV; so upgrading to a more expensive model isn't an option I'd consider. If I can just find the right components, I think I can do this even with one leg because most work would be laying on a creeper (adjusts to sitting, laying and even raising legs). As soon as they said "Oh, you didn't buy this from us" and proceeded to give me the bum rush out of their store I knew I was in a very poorly managed dealership. The problem is that it's the only local dealership that sells anything bigger than glorified pop-ups. As I said, piss on them; they lost my business and the business of all I speak with in the future. Can you imagine dealing with a dealer that has that attitude if you just dropped a couple hundred grand on a coach and you had some minor issues they didn't want to handle?

As far as running the generator; it's a 4 cylinder Kubota diesel with very low hours that seems to just sip fuel. I wouldn't be concerned about putting thousands of hours on it.
 

Dargo

Like a bad penny...
GOLD Site Supporter
If you are willing to run your generator a good bit you could use regular heat tapes and wrap the lines and insulate them. The tanks with some rv antifreeze in them won't be that big of a deal but the valves to dump them will need tape and insulation to protect them going down the highway. I would use foam insulation and good tape like gorilla tape to hold it in place. Fiberglass will absorb water and salt slush too much. Wrap all the lines with the tape running from front to back so the air is less likely to unravel it.

That's sort of what I've read; to be careful about the dump valves and insulate well. I literally have a minimum of 12" or so in even the tightest spaces for applying some sort of heating tape and insulation. That sounds like the way to go if I could just find one good RV place that sells that sort of equipment. Going with the highest quality heaters for the 3 main tanks (the ones with thermostats) and even the high end heat tape with a rheostat to control them along with the same for wrapping the dump valves, I was well under a grand even adding for insulation. I have enough room to even use some marine plywood (and even coat it again with resin) and enclose the areas that are exposed with insulation inside the enclosed areas.
 
Top